1061ss11

12

SUPPORTING STATEMENT

ENVIRONMENTAL PROTECTION AGENCY

NSPS for the Phosphate Fertilizer Industry (40 CFR Part 60, Subparts T, U, V, W, and X) (Renewal)

1. Identification of the Information Collection

1(a) Title of the Information Collection

NSPS for the Phosphate Fertilizer Industry (40 CFR Part 60, Subparts T, U, V, W, and X) (Renewal), ICR Number 1061.11, OMB Control Number 2060-0037

1(b) Short Characterization/Abstract

The New Source Performance Standards (NSPS) for the regulations published at 40 CFR part 60, subparts T, U, V, W, and X were proposed on October 22, 1974, and promulgated on August 6, 1975. These standards apply to each wet-process phosphoric acid plant, each superphosphoric acid plant, each granular diammonium phosphate plant, and each triple superphosphate plant, having a design capacity of more than 15 tons of equivalent phosphorous pentoxide (P₂O₅) feed per calendar day. These standards also apply to granular triple superphosphate storage facilities. These standards establish fluoride emission limitations as a measure of phosphorus-bearing feed material at affected facilities. The affected facilities may include a combination of reactors, filters, evaporators, hot wells, acid sumps, cooling tanks, granulators, dryers, coolers, screens, mills, mixers, curing belts (dens), cookers, and facilities which store run-of-pile triple superphosphate, depending on the type of plant.

In general, all NSPS standards require initial notifications, performance tests, and periodic reports. Owners or operators are also required to maintain records of the occurrence and duration of any startup, shutdown, or malfunction in the operation of an affected facility, or any period during which the mobnitoring system is inoperative. These notifications, reports, and records are essential in determining compliance, and are required of all sources subject to NSPS.

Any owner or operator subject to the provisions of this part shall maintain a file of these measurements, and retain the file for at least two years following the date of such measurements, maintenance reports, and records. All reports are sent to the delegated state or local authority. In the event that there is no such delegated authority, the reports are sent directly to the United States Environmental Protection Agency (EPA) regional office.

Approximately 13 sources are currently subject to the regulation, and it is estimated that no new sources will become subject to the regulation over the next three years. In order to comply with the recordkeeping and reporting requirements standard, the respondents will expend approximately 1,194 hours and $320,190 per year.

These figures are based on queries conducted through the Online Tracking Information System (OTIS); data from the Profile of the Agricultural Chemical, Pesticide, and Fertilizer Industry Sector Notebook published by the EPA Office of Compliance, and the Technical Support Document for Phosphoric Acid Manufacturing and Phosphate Fertilizers Production; queries conducted on the Missouri State Government/Business Entity Database; consultations with the Florida State Government, Office of the Environment and a number of fertilizer companies.

During a previous renewal, the most recent data available on the Air Facility System (AFS) database for the NSPS program associated with the United States Standard Industrial Classification (SIC) codes for the respondents affected by the standards was used. The most recent data on wages from the United States Department of Labor, Bureau of Labor Statistics, March 2001, Table 10. Private industry, by occupational and industry group, and the guidance provided by the EPA Office of Environmental Information and the Office of Management and Budget was also used to calculate the respondent burden. The wage rate obtained from the table was increased by 110 percent to account for the benefit packages available to those employed by private industry.

The active (previous) ICR had the following Terms of Clearance (TOC):

When this ICR is resubmitted for renewal, EPA is reminded that they should include in the supporting statement the name and contact information for consultations with members of the public concerning the collection.

EPA published an announcement of a public comment period for the renewal of this ICR in the Federal Register on July 8, 2009. No comments were received on respondent burden associated with the reporting and recordkeeping requirements provided in this ICR. Additionally, EPA contacted industry representatives to request a voluntary opinion on the accuracy of the burden estimates associated with the collection and the potential for minimizing the burden associated with the collection [see Section 3(c)].

The burden to the “Affected Public” may be found in Table 1: Annual Respondent Burden and Cost. The burden to the “Federal Government” is attributed entirely to work performed by federal employees or government contractors. This burden may be found in Table 2: Average Annual EPA Burden.

2. Need for and Use of the Collection

2(a) Need/Authority for the Collection

The EPA is charged under section 111 of the Clean Air Act (CAA), as amended, to establish standards of performance for new stationary sources that reflect:

. . . application of the best technological system of continuous emissions reduction which (taking into consideration the cost of achieving such emissions reduction, or any non-air quality health and environmental impact and energy requirements) the Administrator determines has been adequately demonstrated. Section 111(a)(l).

The Agency refers to this charge as selecting the best demonstrated technology (BDT). Section 111 also requires that the Administrator review and, if appropriate, revise such standards every four years.

In addition, section 114(a) states that the Administrator may require any owner or operator subject to any requirement of this Act to:

(A) Establish and maintain such records; (B) make such reports; (C) install, use, and maintain such monitoring equipment, and use such audit procedures, or methods; (D) sample such emissions (in accordance with such procedures or methods, at such locations, at such intervals, during such periods, and in such manner as the Administrator shall prescribe); (E) keep records on control equipment parameters, production variables or other indirect data where direct monitoring of emissions is impractical; (F) submit compliance certifications in accordance with Section 114(a)(3); and (G) provide such other information as the Administrator may reasonably require.

In the Administrator's judgment, particulate emissions from the ammonium sulfate manufacturing industry cause or contributed to air pollution that may reasonably be anticipated to endanger public health or welfare. Therefore, NSPS were promulgated for this source category at 40 CFR part 60, subparts T, U, V, W, and X.

2(b) Practical Utility/Users of the Data

Source data and information requirements for phosphate fertilizer plants are outlined in Section 4(b)(i). These standards require the initial reports in accordance with the general provisions of 40 CFR section 60.7. These initial reports include notification of construction or modification, reconstruction, and startup, shutdown, or malfunction. The standards also require recordkeeping to document information relating to the daily feed rate and storage of equivalent P₂O₅. Semiannual compliance reporting is also required by the general provisions.

Amounts of P₂O₅ are determined from Continuous Monitoring System (CMS) records of phosphate-bearing feed material or accounts for triple superphosphate stored. The standards are defined in terms of grams of fluorides emitted per metric ton of equivalent P₂O₅ processed.

The standards limits total fluoride emission to 100 grams per megagram (Mg) of equivalent P₂O₅ feed as measured in Mg/hour. Therefore, the regulations require the hourly recording of data and the maintenance of daily records for purposes of determining the feed rate used in the standard. Such records must be retained at the facility for a minimum of two (2) years.

The information generated by the monitoring, recordkeeping, and reporting requirements described above is used by the Agency to ensure that facilities affected by the NSPS continue to operate and control equipment used to achieve compliance with the NSPS. Notification of construction and startup indicates to enforcement personnel when a new affected facility has been constructed and, therefore, is subject to the standards. Under the standard, data collected by an affected facility is retained at the source for a minimum of two years and made available for inspection by the Administrator.

If the information required by the standards were not collected, the Agency would have no means of ensuring that compliance with the NSPS is achieved and maintained by new, modified, or reconstructed sources subject to the regulations. Under these circumstances, an owner or operator could elect to reduce operating expenses by not installing, maintaining, or otherwise operating the control technology required by the standards. In the absence of the information collection requirements, compliance with the standards could be ensured only through continuous on-site inspections by regulatory Agency personnel. Consequently, not collecting the information would result in either greatly increased expenditures of resources, or the inability to ensure compliance with the standards. Adequate monitoring, recordkeeping, and reporting are necessary to ensure compliance with the applicable regulations, as required by the Clean Air Act. The information collected from recordkeeping and reporting requirements is also used for targeting inspections, and is of sufficient quality to be used as evidence in court.

3. Nonduplication, Consultations, and Other Collection Criteria

The requested recordkeeping and reporting are required under 40 CFR part 60, subparts T, U, V W, and X.

3(a) Nonduplication

If the subject standards have not been delegated, the information is sent directly to the appropriate EPA regional office. Otherwise, the information is sent directly to the delegated state or local agency. If a state or local agency has adopted their own similar standards to implement the Federal standards, a copy of the report submitted to the state or local agency can be sent to the Administrator in lieu of the report required by the federal standards. Therefore, no duplication exists.

3(b) Public Notice Required Prior to ICR Submission to OMB

An announcement of a public comment period for the renewal of this ICR was published in the Federal Register (74 FR 32580) on July 8, 2009. No comments were received on the burden published in the Federal Register.

3(c) Consultations

During a previous renewal of this ICR, several consultations were conducted. First, information available from the Office of Compliance Sector Notebook “Profile of the Agricultural Chemical, Pesticide, and Fertilizer Industry” was reviewed. Then, the most recent data available on the Air Facility System (AFS) database of was accessed. Additionally, information from the “Technical Support Document for Phosphoric Acid Manufacturing and Phosphate Fertilizers Production,” published by the Office of Air Quality Planning and Standards was reviewed. Information was also gathered from Florida State Government, Office of the Environment, the Missouri State Government Business Entity Database, and a number of fertilizer companies.

For this current renewal, EPA contacted representatives of industry trade organizations to request a voluntary opinion as to the accuracy of the burden estimates associated with this ICR and whether there is any way to reduce the burden. Consultation with the Florida Institute for Phosphate Research was conducted, and a representative confirmed that EPA’s estimation of 13 affected facilities is reasonable (Paul Clifford, Ph.D.; phone: 863-534-7160). The Fertilizer Institute was contacted, but did not provide comment (Bill Herz; phone: 202-256-9986).

3(d) Effects of Less Frequent Collection

Less frequent information collection would decrease the margin of assurance that facilities are continuing to meet the standards. Requirements for information gathering and recordkeeping are useful techniques to ensure that good operation and maintenance practices are applied and emission limitations are met. If the information required by these standards was collected less frequently, the likelihood of detecting poor operation and maintenance of control equipment and noncompliance would decrease.

3(e) General Guidelines

None of these reporting or recordkeeping requirements violate any of the regulations established by OMB at 5 CFR 1320.5.

3(f) Confidentiality

The required information has been determined not to be confidential. However, any information submitted to the Agency for which a claim of confidentiality is made will be safeguarded according to the Agency policies set forth in title 40, chapter 1, part 2, subpart B - Confidentiality of Business Information (CBI) (see 40 CFR 2; 41 FR 36902, September 1, 1976; amended by 43 ­FR 40000, September 8, 1978; 43 FR 42251, September 20, 1978; 44 FR 17674, March 23, 1979).

3(g) Sensitive Questions

None of the reporting or recordkeeping requirements contain sensitive questions.

4. The Respondents and the Information Requested

4(a) Respondents/SIC Codes

The respondents to the recordkeeping and reporting requirements are phosphate fertilizer facilities. The United States Standard Industrial Classification (SIC) code for the respondents affected by the standard is 2874, and the North American Industry Classification System (NAICS) code is 325312.

4(b) Information Requested

(i) Data Items

All data in this ICR that is recorded and/or reported is required by NSPS for the Phosphate Fertilizer Industry (40 CFR part 60, subparts T, U, V, W, and X).

A source must make the following reports:

Reports for 40 CFR part 60, subparts T, U, V, W, and X
Notification of construction/reconstruction.	60.7(a)(1)
Notification of initial startup including compliance method.	60.7(a)(3)
Initial performance test results.	60.8(a)
Initial performance test.	60.8(d)
Demonstration of continuous monitoring system.	60.7(a)(5)
Physical or operational change.	60.7(a)(4)
Semiannual or as indicated by the Administrator reports of exceedances or monitoring systems performance.	60.7(c)
Site-specific methodology plan for demonstrating compliance with standards for fluorides.	60.242(a), 60.243(d)

A source must maintain the following records:

Recordkeeping for 40 CFR part 60, subparts T, U, V, W, and X
Startups, shutdowns or malfunctions, periods where the continuous monitoring system is inoperative.	60.7(b)
A file with records of all data measured during performance tests to demonstrate compliance with the standard including the equipment operating parameters and records of periods of operations during which the parameters where established. The file shall be retained for two years following the date of such measurements, maintenance, reports, and records.	60.7(f)
Daily record of equivalent P2O5 feed rate.	60.203(b), 60.213(b) 60.223(b), 60.233
Daily record of equivalent P2O5 feed rate and storage.	60.243(b)
Other records specified in an EPA approved site-specific plan.	60.243(d)

(ii) Respondent Activities

Respondent Activities

Read instructions.

Install, calibrate, maintain, and operate monitoring devices that continuously measures the total pressure drop across the process scrubbing system.

Install, calibrate, maintain, and operate a flow monitoring device which can be used to determine the mass flow of phosphorus bearing feed material to the process.

As part of the performance test, determine the phosphorus pentoxide content in megagrams per hour (R_p) of the feed, using the Association of Official Analytical Chemists (AOAC) Method 9 and Method 13A or 13b to determine the total fluoride concentration of volumetric flow rate of the effluent gas from each of the emission points.

Write the notifications and reports listed above.

Enter information required to be recorded above.

Submit the required reports developing, acquiring, installing, and utilizing technology and systems for the purpose of collecting, validating, and verifying information.

Develop, acquire, install, and utilize technology and systems for the purpose of processing and maintaining information.

Develop, acquire, install, and utilize technology and systems for the purpose of disclosing and providing information.

Adjust the existing ways to comply with previously applicable instructions and requirements.

Train personnel to be able to respond to a collection of information.

Transmit, or otherwise disclose the information.

Currently, sources are using monitoring equipment that provides parametric data in an automated way (e.g., pressure drop and volumetric flow rate). Although personnel at the source still need to evaluate the data, this type of monitoring equipment has significantly reduced the burden associated with monitoring and recordkeeping. In addition, some regulatory agencies are setting up electronic reporting systems to allow sources to report electronically which is reducing the reporting burden. However, electronic reporting systems are still not widely used by the regulatory agencies.

5. The Information Collected: Agency Activities, Collection Methodology, and Information Management

5(a) Agency Activities

EPA conducts no activities in connection with the acquisition, analysis, storage, and distribution of the required information.

Agency Activities

Observe initial performance tests and repeat performance tests if necessary.

Review notifications and reports, including performance test reports, and quarterly reports of excess emissions reports or semiannual reports of no excess emission, required to be submitted by industry.

Audit facility records.

Input, analyze, and maintain data in the AIRS (Aerometric Information Retrieval System) Facility Subsystem (AFS) database.

5(b) Collection Methodology and Management

All reports are sent to the delegated state or local authority. In the event that there is no such delegated authority, the reports are sent directly to the EPA regional office. Notifications are used to inform the Agency or delegated authority when a source becomes subject to the standard. Data and records maintained by the respondents are tabulated and published for use in compliance and enforcement programs. The semiannual reports of exceedances are used for problem identification, as a check on source operation and maintenance, and for compliance determinations.

Information contained in the reports is entered into Air Facility System (AFS) which is operated and maintained by the EPA Office of Compliance. AFS is the EPA database for the collection, maintenance, and retrieval of compliance and annual emission inventory data for over 100,000 industrial and government-owned facilities. EPA uses AFS for tracking air pollution compliance and enforcement activity by local and state regulatory agencies, EPA regional offices and EPA headquarters. EPA and its delegated Authorities can edit, store, retrieve and analyze the data. The records required by this regulation must be retained by the owner or operator for two years.

5(c) Small Entity Flexibility

Currently the number of employees at a typical fertilizer plant exceeds the criterion for small business, and no new facilities are expected within the next three years. Due to technical considerations involving the process operations and the types of control equipment employed, the recordkeeping and reporting requirements are the same for both small and large entities. The Agency considers these requirements the minimum needed to ensure compliance and, therefore cannot reduce them further for small entities.

The specific frequency for each information collection activity within this request is shown in Table 2: Annual Industry Burden - NSPS for the Phosphate Fertilizer Industry (40 CFR part 60, subparts T, U, V, W and X).

5(d) Collection Schedule

The specific frequency for each information collection activity within this request is shown in below Table 1: Annual Respondent Burden and Cost.

6. Estimating the Burden and Cost of the Collection

Table 1 documents the computation of individual burdens for the recordkeeping and reporting requirements applicable to the industry for the subparts included in this ICR. The individual burdens are expressed under standardized headings believed to be consistent with the concept of burden under the Paperwork Reduction Act. Where appropriate, specific tasks and major assumptions have been identified. Responses to this information collection are mandatory.

The Agency may not conduct or sponsor, and a person is not required to respond to, a collection of information unless it displays a currently valid OMB Control Number.

6(a) Estimating Respondent Burden

The average annual burden to industry over the next three years from these recordkeeping and reporting requirements is estimated to be 1,194 hours (Total Labor Hours from Table 1). These hours are based on agency studies and background documents from the development of the regulation, agency knowledge and experience with the NSPS program, the previously approved ICR, and any comments received.

6(b) Estimating Respondent Costs

(i) Estimating Labor Costs

This ICR uses the following labor rates:

Managerial $114.77 ($54.65 + 110%)

Technical $97.59 ($46.47 + 110%)

Clerical $48.26 ($22.98 + 110%)

These rates are from the United States Department of Labor, Bureau of Labor Statistics, March 2009, Table 2. Civilian Workers, by occupational and industry group. The rates are from column 1, Total compensation. The rates have been increased by 110 percent to account for the benefit packages available to those employed by private industry.

The previous ICR used only a technical labor rate from 2001. The updated labor categories and associated rates result in a change to total labor cost.

(ii) Estimating Capital/Startup and Operation and Maintenance Costs

The type of industry costs associated with the information collection activity in the regulations is labor and continuous emission monitoring (CEM). There are no capital/startup costs since we have assumed that no new sources will become subject to this rule over the three-year period of this ICR. The capital/startup costs are one-time costs when a facility becomes subject to the regulation. The annual operation and maintenance costs are the ongoing costs to maintain the monitor and other costs such as photocopying and postage which are itemized in the following table.

(iii) Capital/Startup vs. Operation and Maintenance (O&M) Costs

Capital/Startup vs. Operation and Maintenance (O&M) Costs
(A) Continuous Monitoring Device	(B) Startup Cost for One Source	(C) Number of New Sources to Startup	(D) Total Startup (B X C)	(E) Annual O&M Costs for One Source	(F) Number of Existing Sources with O&M	(G) Total O&M (E X F)
Pressure drop monitor	$27,720	0	$ 0	$24,630	13	$320,190

As indicated above, there are no capital/startup costs for this ICR. This is the total of column D in the above table.

The total operation and maintenance (O&M) costs for this ICR is $320,190. This is the total of column G.

6(c) Estimating Agency Burden and Cost

The only costs to the Agency are those costs associated with analysis of the reported information. EPA's overall compliance and enforcement program includes activities such as the examination of records maintained by the respondents, periodic inspection of sources of emissions, and the publication and distribution of collected information.

The average annual Agency cost during the three years of the ICR is estimated to be $1,154 (see Table 2).

This cost is based on the average hourly labor rate as follows:

Managerial $61.36 (GS-13, Step 5, $38.35 + 60%)

Technical $45.52 (GS-12, Step 1, $28.45 + 60%)

Clerical $24.64 (GS-6, Step 3, $15.40 + 60%)

These rates are from the Office of Personnel Management (OPM), 2009 General Schedule, which excludes locality rates of pay. The rates have been increased by 60% to account for the benefit packages available to government employees.

6(d) Estimating the Respondent Universe and Total Burden and Costs

Respondent Universe and Number of Responses Per Year
Regulation Citation	(A) Average Number of New Respondents per Year	(B) Number of Reports for New Sources	(C) Number of Existing Respondents	(D) Number of Reports for Existing Sources	(F) Number of Respondents That Keep Records But Do Not Submit Reports	(E) Total Annual Responses (AxB)+(CxD)+F
40 CFR Part 60, Subparts T, U, V, W, and X	0	6	13	2	0	26

The number of total respondents is 13. This number is the sum of column A and column C of the Respondent Universe and Number of Responses Per Year table. This represents the number of existing sources plus the number of new sources averaged over the three-year period.

The number of Total Annual Responses is 26. This is the number in column E of the Respondent Universe and Number of Responses Per Year table.

The total annual labor costs are $117,512. Details upon which this estimate is based appear in Table 1: Annual Respondents Burden - NSPS for the Phosphate Fertilizer Industry, (40 CFR part 60, subparts T, U, V, W, and X).

The total annual capital and O&M costs to the regulated entity are $320,190. These costs are detailed in Section 6(b)(iii), Capital/Startup vs. Operating and Maintenance (O&M) Costs.

6(e) Bottom Line Burden Hours and Cost Tables

The bottom line burden hours and cost tables for both the Agency and the respondents are attached.

6(f) Reasons for Change in Burden

There is no change in the labor hours in this ICR compared to the previous ICR. This is due to two considerations. First, the regulations have not changed over the past three years and are not anticipated to change over the next three years. Secondly, the growth rate for respondents is very low, negative, or non-existent. Therefore, the labor hours in the previous ICR reflect the current burden to the respondents and are reiterated in this ICR. There is a minor change to the cost figures, since the previous ICR used a technical labor rate only. The updated labor categories and associated rates result in an increase to total labor cost. Additionally, the previous ICR rounded to the nearest $1,000. This ICR presents cost figures which differ by less than $500 from the previous ICR due to using exact figures instead of rounding.

6(g) Burden Statement

The annual public reporting and recordkeeping burden for this collection of information is estimated to average 46 hours per response. Burden means the total time, effort, or financial resources expended by persons to generate, maintain, retain, or disclose or provide information to or for a Federal agency. This includes the time needed to review instructions; develop, acquire, install, and utilize technology and systems for the purposes of collecting, validating, and verifying information, processing and maintaining information, and disclosing and providing information; adjust the existing ways to comply with any previously applicable instructions and requirements; train personnel to be able to respond to a collection of information; search data sources; complete and review the collection of information; and transmit or otherwise disclose the information.

An agency may not conduct or sponsor, and a person is not required to respond to, a collection of information unless it displays a valid OMB Control Number. The OMB Control Numbers for EPA regulations are listed at 40 CFR part 9 and 48 CFR chapter 15.

To comment on the Agency's need for this information, the accuracy of the provided burden estimates, and any suggested methods for minimizing respondent burden, including the use of automated collection techniques, EPA has established a public docket for this ICR under Docket ID Number EPA-HQ-OECA-2009-0417. An electronic version of the public docket is available at http://www.regulations.gov/ which may be used to obtain a copy of the draft collection of information, submit or view public comments, access the index listing of the contents of the docket, and to access those documents in the public docket that are available electronically. When in the system, select “search,” then key in the docket ID number identified in this document. The documents are also available for public viewing at the Enforcement and Compliance Docket and Information Center in the EPA Docket Center (EPA/DC), EPA West, Room 3334, 1301 Constitution Avenue, N.W., Washington, D.C. The EPA Docket Center Public Reading Room is open from 8:30 a.m. to 4:30 p.m., Monday through Friday, excluding legal holidays. The telephone number for the Reading Room is (202) 566-1744, and the telephone number for the docket center is (202) 566-1752. Also, you can send comments to the Office of Information and Regulatory Affairs, Office of Management and Budget, 725 17th Street, N.W., Washington, D.C. 20503, Attention: Desk Officer for EPA. Please include the EPA Docket ID Number EPA-HQ-OECA-2009–0417 and OMB Control Number 2060-0037 in any correspondence.

Part B of the Supporting Statement

This part is not applicable because no statistical methods were used in collecting this information.

TABLE 1: ANNUAL RESPONDENT BURDEN AND COST - NSPS for the PHOSPHATE FERTILIZER INDUSTRY (40 CFR PART 60, SUBPARTS (T, U, V, W, AND X)

Burden Item	A Hours per Occurrence	B Number of occurrences per respondent per year	C Hours per respondent per year (AxB)	D Respondents per yearb	E Management hours per year	F Technical hours per year	G Clerical hours per year	H Employee hours per year (E+F+G)	I Total cost per year ($)a
1. RECORDKEEPING REQUIREMENTS	N/A
2. SURVEY AND STUDIES	N/A
3. REPORTING REQUIREMENTS
A. Read Instructions	1	1	1	0	0.00	0.00	0.00	0.00	0.00
B. Required activities
New Sources
Initial Performance Test
AOCA Method 9 testsc	29.7	1	29.7	0	0.00	0.00	0.00	0.00	0.00
Reference Method 13A or 13B testsd	4	1	4	0	0.00	0.00	0.00	0.00	0.00
Repeat performance teste	4	0.2	0.8	0	0.00	0.00	0.00	0.00	0.00
C. Create information	Included in 3B
D. Gather existing information	Included in 3E
E. Write Report
New Sources
Notification of construction/ reconstruction	2	1	2	0	0.00	0.00	0.00	0.00	0.00
Notification of actual startup	2	1	2	0	0.00	0.00	0.00	0.00	0.00
Notification of initial performance test	2	1	2	0	0.00	0.00	0.00	0.00	0.00
Notification of CMS demonstration	2	1	2	0	0.00	0.00	0.00	0.00	0.00
Report of initial performance test	Included in 3B
Site-specific methodology planf	2	1	2	0	0.00	0.00	0.00	0.00	0.00
Existing Sources
Notification of operational changeg	2	1	2	2	0.17	3.48	0.35	4.00	376.19
Semiannual report of exceedancesh	2	2	4	13	2.26	45.22	4.52	52.00	4,890.46
Reporting Subtotal								56 (rounded)	5,267
4. RECORDKEEPING REQUIREMENTS	0.75		0
A. Read Instructions	Included in 3A
B. Plan activities	Included in 3B
C. Implement activities	Included in 3B
D. Develop record system	N/A
E. Time to enter information
Records of operationg parameters and emissionsi	0.25	350	87.5	13	49.46	989.13	98.91	1,137.50	106,978.91
Recordkeeping Subtotal								1,138 (rounded)	106,979
TOTAL ANNUAL BURDEN								1,194	117,512.22

Assumptions:

a. This ICR uses the following labor rates: Managerial $114.77 ($54.65 + 110%); Technical $97.59 ($46.47 + 110%); and Clerical $48.26 ($22.98 + 110%).

These rates are from the United States Department of Labor, Bureau of Labor Statistics, March 2009, ATable 2. Civilian Workers, by occupational and industry group.@ The rates are from column 1, ATotal compensation.@ The rates have been increased by 110 percent to account for the benefit packages available to those employed by private industry. This ICR assumes that Managerial hours are 5 percent of Technical hours, and Clerical hours are 10 percent of Technical hours.

b. We assume that there will be no new sources (respondents) over the 3 year-period of this ICR.

c. As specified in the general provisions, each performance test shall consist of three separate runs using the applicable test method. Sources are required to use the spectrophotometric molybdovanadophosphate method (AOAC) Method 9 published in the 11 Edition of the Official Methods of Analysis of the Association of Official Analytical Chemists dated 1970, to determine the P₂O₅ feed rate.

d. As specified in the general provisions, each performance test shall consist of three separate runs using the applicable test method. Each run shall be conducted

for the time and under the conditions specific in the applicable rule. For these rules, the total fluoride concentration and volumetric flow rate of the effluent gas shall

be determined by Method 13 which requires a sampling time and a sample volume for each run of at least 60 minutes and 0.85 dscm (30 dscf).

e. We assume that 20 percent of initial performance tests must be repeated due to failure.

f. Only sources that have a granular triple superphosphate storage facility are required to submit this initial plan.

g. We assume that 15 percent of the source would be attributed to operational changes.

h. We assume that each source will submit a semiannual report due to excess emission and monitoring systems performance over the three-year period.

i. Sources are required to maintain a daily record of operating parameters (e.g., determine equivalent P₂O₅ content, and total pressure drop across the scrubbing system). We assume that the operation is 350 days per year as specified in the NSPS review document.

TABLE 2: AVERAGE ANNUAL EPA BURDEN - NSPS for the PHOSPHATE FERTILIZER INDUSTRY (40 CFR PART 60, SUBPARTS T, U, V, W, and X)

Burden Item	A EPA Hours per Occurrence	B Number of occurrences per plant per year	C EPA hours per plant per year (AxB)	D Plants per yearb	E EPA management hours per year	F EPA technical hours per year	G EPA clerical hours per year	H Employee hours per year (E+F+G)	I Total cost per yeara ($)
1. REPORT REVIEW
New Plants
Notification of construction/reconstruction	2	1	2	0	0.00	0.00	0.00	0.00	0.00
Notification of initial startup	0.5	1	0.5	0	0.00	0.00	0.00	0.00	0.00
Notification of actual startup	0.5	1	0.5	0	0.00	0.00	0.00	0.00	0.00
Notification of initial test	0.5	1.2	0.6	0	0.00	0.00	0.00	0.00	0.00
Review test results	8	1.2	9.6	0	0.00	0.00	0.00	0.00	0.00
Notification of CMS demonstration	0.5	1	0.5	0	0.00	0.00	0.00	0.00	0.00
Existing Plants
Semiannual report	1	2	2	13	1.13	22.61	2.26	26.00	1,154.22
TOTAL ANNUAL BURDEN								26	1,154

Assumptions:

a. This cost is based on the average hourly labor rate as follows: Managerial $61.36 (GS-13, Step 5, $38.35 + 60%); Technical $45.52 (GS-12, Step 1, $28.45 + 60%); and Clerical $24.64 (GS-6, Step 3, $15.40 + 60%). This ICR assumes that Managerial hours are 5 percent of Technical hours, and Clerical hours are 10 percent of Technical hours.

b. We assume that there will be no new sources (respondents) over the 3-year period of this information collection request (ICR).